Tractor Won’t Shutoff

[hsargent21]

I have a Mahindra (TYM) 4110 that won’t shutoff when you turn the key off. It’s been like this for years. We have always just pulled the t-handle to kill the tractor. Well I thought it was a bad solenoid so I ordered one. Installed it today and it still doesn’t work. Not getting power to the solenoid. Is there a fuse panel on this tractor? I haven’t been able to find one. Inline fuse to check? Any other ideas? Thanks in advance

 

[KS KIOTI]

Check your negative battery cables ground to the frame. Detach the cable from the frame, wire brush it and the cable and reattach.

 

[hsargent21]

Copy. I will do that today

 

[skipmarcy]

There is a timer in the circuit, I think it's in the dash. When you turn the key off, it energizes the solenoid for maybe 10 or 15 seconds +/- to kill the fuel then will de-energize and let the solenoid release for the next start. You should have a small fusebox under the hood at the firewall - my 2001 model does. My system has always worked electrically like it's supposed to but on very rare occasion the solenoid alone would not kill the engine and I had to pull the T handle in addition to the solenoid working.

 

[SPYDERLK]

There is a timer in the circuit, I think it's in the dash. When you turn the key off, it energizes the solenoid for maybe 10 or 15 seconds +/- to kill the fuel then will de-energize and let the solenoid release for the next start. You should have a small fusebox under the hood at the firewall - my 2001 model does. My system has always worked electrically like it's supposed to but on very rare occasion the solenoid alone would not kill the engine and I had to pull the T handle in addition to the solenoid working.

Nice that yous are provided the "T handle". My 7520 does not have one - or didnt until I noticed and rigged up that IMPORTANT kill option.

 

[hsargent21]

Found the fuse panel. Looks like the fuse powers the key switch and the PTO. Fuse looks good and the PTO works. So must be the timer. Looked that part up. $199. Looks like I will just continue pulling the t-handle. Lol

 

[Offroadtek]

What's the part number for that relay? I found it. PartsASAP has them for $94 on amazon, Amazon.com: All States Timer Relay fits Kioti CK20 CK25 CK27 15475-60243 15475-6024-2 : Patio, Lawn & Garden . But $104 from the PartsASAP site directly.

And while I'm here, where's the T-handle at? I've never had need for it on my 3510, but I would like to know.

 

[hsargent21]

What's the part number for that relay? I found it. PartsASAP has them for $94 on amazon, Amazon.com: All States Timer Relay fits Kioti CK20 CK25 CK27 15475-60243 15475-6024-2 : Patio, Lawn & Garden . But $104 from the PartsASAP site directly.

And while I'm here, where's the T-handle at? I've never had need for it on my 3510, but I would like to know.

On my tractor it down below the steering wheel by my right foot

 

[coast40]

When this happened on excavator I needed to replace the ignition switch. Works fine now. Now my Mitsubishi Dozer is starting to do the same thing, I bought two switches at the time so I have matching keys now.