Series 3000 quits when Hot

   / Series 3000 quits when Hot #1  

GTSRider

Gold Member
Joined
Jun 26, 2010
Messages
316
Tractor
Cub Cadet 3000
After about an hour of perfect running... my series 3000 with
the 20hp Command engine, sputters and will quit.... then it will not restart untill cold .
Engine has 750 hard hrs. on it .... with recent new coil.... only one replaced.
What's going on here ?
Thanks....
Pete
 
   / Series 3000 quits when Hot #2  
Have you checked for spark when it dies?
 
   / Series 3000 quits when Hot #3  
If you have spark, pull the cap on the fuel tank when it dies. If you hear a hiss and/or it starts right up with the cap loose/off, replace the cap as the vent is plugged.

Aaron Z
 
   / Series 3000 quits when Hot
  • Thread Starter
#4  
No , I will check next time it dies... but it seems not to , as raw fumes, and smoke emege from tailpipe, when strter is cracnked after it dies.
Assuming it has no spark...what would cause this ?
New coil is about 6 weeks old. Would a faulty rectifier cause something like this ?
 
   / Series 3000 quits when Hot #5  
No , I will check next time it dies... but it seems not to , as raw fumes, and smoke emege from tailpipe, when strter is cracnked after it dies.
Assuming it has no spark...what would cause this ?
New coil is about 6 weeks old. Would a faulty rectifier cause something like this ?

You could have a bad coil.
 
   / Series 3000 quits when Hot #6  
OP - could also have trash buildup under engine cowling causing heat buildup affecting coil....
 
   / Series 3000 quits when Hot
  • Thread Starter
#7  
Just quit again after 25 minutes of mowing... anyone have any ideas ?
No spark at all...but runs like new for the first 25- 45 minutes....
 
   / Series 3000 quits when Hot #8  
Bad coil.. Bad spark plug (drives you nuts, had it happen 2x)... Change the plugs and coil(s).
 
   / Series 3000 quits when Hot
  • Thread Starter
#9  
Thanks.... I will change plugs first...and if that don't do it... I guess I will put in 2 new coils... but one is only about 6 weeks old...
possibly a defective new unit.... don't know.
 
   / Series 3000 quits when Hot
  • Thread Starter
#10  
Good tip....checked cylinders , and they are clear...dealer cleaned them when coil was installeed in August.
Going to install new plugs today...even though new in August....could be new defective...
 

Tractor & Equipment Auctions

2022 BOBCAT T595 SKID STEER (A51242)
2022 BOBCAT T595...
2009 Lee-Boy 8510HD Conveyer Feed paver (A51039)
2009 Lee-Boy...
2009 Yamaha YDRE Electric Cart (A50324)
2009 Yamaha YDRE...
2012 LINDE H80D FORKLIFT (A50854)
2012 LINDE H80D...
2019 Caterpillar 815K Articulated Compactor (A49461)
2019 Caterpillar...
2016 Nissan NV200 Cargo Van (A50323)
2016 Nissan NV200...
 
Top