John Deere 4520 intermittent starting problem

   / John Deere 4520 intermittent starting problem #1  

Trainpilot

New member
Joined
May 3, 2017
Messages
6
Location
ukiah
Tractor
Kubota M9580, 6030, M8200N; John Deere 4520, 770
We have a 2014 4520 with about 1200 hours. It only starts intermittently. When it starts it runs fine. Whether it just cranks or starts, it shows an error 207 code. After 3 trips to the dealership asking about it, they figured out that the code indicates a fault with the engine position sensor. I changed the sensor on the front middle of the engine to no effect. (a $35.00 part) A JD tech came and hooked up a couple of black boxes to the tractor and could not figure out what the issue was. He said he would send the files to JD and that they would tell him what was wrong. Several days later, the service mgr informed me that the controller is bad ($2000.00 + labor). I have not yet given them the go ahead, but we're going to need the tractor soon. I'm wondering if anyone else has had a similar experience or has any good suggestions. 4120, 4320, 4520, 4720 are all in this series. CRD with a black box controlling everything. It tells you if you have a burned out tail light, but can't diagnose itself. The manual gives a very short list of error codes--as I mentioned, even a determined tech had trouble finding out what error 207 was. I have a good relationship with this dealership and have asked for some help vs the cost of the controller, as I think it was still under warranty when it failed.
 
   / John Deere 4520 intermittent starting problem #2  
Check the "Similar Threads" at the bottom of the page.

Because it's an intermittent fault I'd also suspect a 'sticky' relay (located in the fuse area). You could swap the relays around as they're usually the same type... but you may not know right away, due to the intermittent nature of the fault, if it has been solved. Purchasing a replacement relay (inexpensive) would be the way I'd go.

Vibration, especially with the amount of hours on your 4520, can cause the weirdest faults. :)
 

Tractor & Equipment Auctions

2015 Timpte Hopper Bottom (A50514)
2015 Timpte Hopper...
2010 Keystone Cougar 5th Wheel T/A Travel Trailer (A48082)
2010 Keystone...
AIR POWERED TONGS (A50854)
AIR POWERED TONGS...
2014 MACK CXU (PINNACLE) (A50854)
2014 MACK CXU...
2019 CATERPILLAR 308 CR EXCAVATOR (A51242)
2019 CATERPILLAR...
2013 INTERNATIONAL PAYSTAR DAY CAB ROAD TRACTOR (A51406)
2013 INTERNATIONAL...
 
Top