Mowing F3680 Cutting out

   / F3680 Cutting out #1  

VicinOz

New member
Joined
Apr 18, 2011
Messages
4
Tractor
MF148
Hi all,

My 3680 goes great, but every so often, about once every five or ten hours, it just stops.
It will sometimes start right up and run for the rest of the day, and other times, it won't start again until the next day, or after a long rest.
When it stops, its like the stop solenoid - its that quick, so I replaced that. No better.
I also had an issue with the brake microswitch, so replaced that a while ago.
When I start it and it won't keep running, it does run until you let go of the starter, then it just dies immediately.

Any ideas would be appreciated!

Cheers, :confused:

Vic
 
   / F3680 Cutting out #2  
If your solenoid is a 3 wire sol.? there are relays that make it run. Theres a "start" relay & a "hold" relay..
It sounds as if your "hold" relay is shot.. or the key switch is bad..
If you have a service manual, that should tell u where the relays are{I don't know}
THIS IS a very common problem..
 
   / F3680 Cutting out
  • Thread Starter
#3  
Thanks for the speedy reply! I'll check it out in the manual and locate the solenoids. Thanks fully it's currently 'bust' so I may be able to isolate which one it is.
Cheers
 
   / F3680 Cutting out #4  
Let us know what you find out.
 
   / F3680 Cutting out #5  
IF you have to move it or NEED to run it, just remove the solenoid & tape/plug the hole..
Just remember, you wont be able to shut it down w/ the key switch..
Look at how the sol. works.. you'll have to reach in the hole & push the control rack..
OR.. the machine might have a manual shut down lever on it.. should be by the throttle lever..
Good luck.
 

Tractor & Equipment Auctions

Wolverine 72" Skid Steer Sickle Bar Mower (A50515)
Wolverine 72" Skid...
2019 CATERPILLAR D6T LGP HI TRACK CRAWLER DOZER (A51242)
2019 CATERPILLAR...
Quick Attach Log Splitter (A50515)
Quick Attach Log...
2 Axle Deckover Trailer (A50774)
2 Axle Deckover...
2010 Ford Edge SE SUV (A51694)
2010 Ford Edge SE...
2015 Chrysler Town & County Van (A50324)
2015 Chrysler Town...
 
Top