battery overcharging
- Thread starter marler
- Start date
- Views: 28944
SSdoxie
Elite Member
If the battery has a shorted cell it can cause an excess voltage draw so alternator would be put out extra volts trying to keep up.
murphy1244
Super Star Member
- Joined
- Nov 25, 2011
- Messages
- 16,336
- Location
- Ohio
- Tractor
- Kubota 1120 RTV Kioti DK-40, MF-135, Ventrac 4500Y
What is the battery voltage while the tractor is off?
JimRB
Veteran Member
I had to jump my tractor. This was a few years ago but seem to recall that the charging voltage was way high. New battery and the charging voltage was fine. I would not put a new alternator on without having the old one bench tested. Way too much money to toss around.
Most battery chargers now have a battery and alt test mode. I would look into one before a battery or alt. They are much cheaper and can be used on about any thing.
17volts does seem a little high. Should be more like 14/15volts.
17volts does seem a little high. Should be more like 14/15volts.
murphy1244
Super Star Member
- Joined
- Nov 25, 2011
- Messages
- 16,336
- Location
- Ohio
- Tractor
- Kubota 1120 RTV Kioti DK-40, MF-135, Ventrac 4500Y
If your measuring voltage at the battery you should have 12.5 to 13.5 with engine off. Fire up engine and your voltage should jump to 15.5 or so volts. As the engine runs the voltage should drop to 12.5 to 13.5 volts. If your voltage does not drop after engine is running for a bit your voltage regulator is not working.
Coyote machine
Super Member
- Joined
- May 4, 2009
- Messages
- 7,641
- Location
- Southern VT
- Tractor
- 22 SANY SY 50U, '10 Kioti DK 40se/hst KL-401 FEL, loaded tires, KB-2485 bhoe, Tuffline TB160 BB, Woods QA forks, MIE Hydraulic bhoe thumb & ripper tooth, Igland 4001 winch, & GR-20 Log Grapple. Woods BBX72" Brush Mower. Diamondplate aluminum canopy
17.xx is way too much output- enough to cause the battery to explode and throw acid all over you and everything else around it. While wearing safety glasses, long sleeved shirt and gloves, CAREFULLY remove the negative battery terminal and then the positive and place the battery in something safe, (HD plastic or wood crate or something similar, with a blanket or some such thing to cover it during transport). Have it load tested at a local facility after explaining what its been reading at 17.xx volts. Evidently the alternator is not your issue. By load testing the battery and checking the specific gravity of each cell you will be able to rule out the battery or find that it is indeed the problem. Report back results, and be careful; no one wants to experience a battery explosion under any circumstances.
