John Deere won’t start

   / John Deere won’t start #11  
Checked at battery only. When working cranks without hesitation. Seems like something is breaking connection at some point.
 
   / John Deere won’t start #12  
Typical "chain of command" on those tractors is the start signal begins with key switch. One tiny wire from there leads to the PTO switch. From there another tiny wire to the neutral switch. Then it goes back up to the actual start relay which is under the cluster in the steering column area.

You might look at the fuse link. That's on the right side of the motor near the intake manifold and grid heater (if you have one) I've seen a few failures there where the fuse wire isn't quite up to task and will actually melt the insulation and the wire yet still perform but only partially carry the load.
 
   / John Deere won’t start #13  
Suggest testing the battery (or have it tested) under load.
I'm thinking a new battery is due or past due. But also remove and clean all battery cable connections. Easy to do these two things.
 
   / John Deere won’t start
  • Thread Starter
#14  
Through trial and error I found it to be (I think) the neutral switch. After using I tilt the bucket a little and lower to prevent any chance of rolling and leave it in neutral. Cranks every time. I did forget once and left it in gear and wouldn’t start. Put in neutral and it would start a few hours later.
 
   / John Deere won’t start #15  
All good info and suggestions. Will dig into more.
 
   / John Deere won’t start #16  
Conclusion in no start issue discovered late last night. Turned out to be a loose positive battery terminal connection. Good voltage at key switch until attempting to crank. Good voltage on battery. Certain I checked ground side but apparently never checked positive side connection. Glad it was something simple but can be frustrating when realize is something you know to check early on but don’t.
 

Tractor & Equipment Auctions

2015 Kenworth T400 T/A Vactor 2100 Plus Combination Sewer Jetter Vacuum Truck (A50323)
2015 Kenworth T400...
2012 BMW 328i (A50324)
2012 BMW 328i (A50324)
2015 CATERPILLAR D3K2 LGP CRAWLER DOZER (A51242)
2015 CATERPILLAR...
UNUSED FUTURE EXCAVATOR RIPPER (A51244)
UNUSED FUTURE...
2019 MDB FM180 FINISHING MOWER (A51243)
2019 MDB FM180...
2019 VOLVO VNL HIGH ROOF SLEEPER (A50046)
2019 VOLVO VNL...
 
Top