Fuel cap and well weaknesses. A dangerous situation by design, dangerous for the tractor's engine.
Kioti DK35, early 2003 build.
I use the term, "conspiracy" to mean that one design weakness we might get away with but when combined with another and another and add environmental factors and...
I don't see anywhere a proper Kioti designation of DK35CR. It is a real designation? I see DK35SE or DK35 only.
Can anyone help with this? (I have a 2003 Kioti DK35).
I bought a Wolverine Fuel Filter heater for my Kioti DK35 2003
It wraps around filters and the like to pre-heat the fuel and prevent gelling when it's very cold.
Is there any risk that it might melt the clear plastic fuel filter "debris" bowl?
I forgot to mention that one of the biggest pains was taking the throttle hand control arm off. It's held on with a pin. That darn pin wouldn't come out without some cursing. If you don't take that arm off then you can't lift the instrument panel out enough to get access to the back of the...
I just changed the Kioti DK35 Hydraulic oil filter. My tractor is approximate 2003 vintage.
The hydraulic oil filter would not come off.
The hydraulic oil filter wouldn't come loose.
It's a very large filter both in length and in diameter (approx 4.25 inches) or over 100 mm. Very few wrenches...
My Kioti DK35 tractor tachometer and hour meter haven't been running.
The tachometer cable broke at about 550 hours.
Broken Kioti DK35 tachometer
Broken hour meter
With some research for the DK35, it's a mechanical cable to the tachometer and hour meter, not electrical.
I found the end in the...
I totally agree. All the linkages I looked at have poor geometry.
Worse, many of them have designs that are extremely prone to rust, wear, debris. This would hinder any shifting movements and interrupt the linkage function.
I went back underneath with my camera and a note book.
For the high...
I bought it from Amazon because I have Prime and the shipping would add to much to an already "high" cost for a seat. I got t his one:
Grammer MSG65/531 Gray Vinyl Mechanical Suspenion Seat
I needed to solve the back-killing ride, when mowing big fields, especially. I was literally standing...
My 2003 era Kioti DK 35 would not shift out of 4x4.
Resolved!
The shift lever is a T-handle on the floor. Pull up to release, push down to engage. It was completely frozen in the down position. Unmovable.
I read all the forums and tried everything. Nothing worked. I tried raising the front...